aqueous extraction of residual oil from sunflower press cake using a

  • Aqueous extraction of residual oil from sunflower press

    The aqueous extraction of the residual oil from sunflower press cakes was carried out using the twin-screw extrusion technology. However, the introduction of wheat straw used as a lignocellulosic residue upstream from the filtration module was essential to enable the liquid/solid separation.

    Get Price

  • (PDF) Aqueous extraction of residual oil from sunflower

    PDF | The objective of this study was to evaluate the feasibility of an aqueous process to extract the residual oil from sunflower press cakes using a co-rotating twin-screw extruder.

  • Images of aqueous extraction of residual oil from sunflower press c… See more images of aqueous extraction of residual oil from sunflower press cake using a
  • [PDF]Aqueous extraction of residual oil from sunflower press

    Rigal, Luc Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: Feasibility study. (2009) Industrial Crops and Products, vol. 2 (n° 2-3). pp. 455-465. ISSN 0926-6690 Open Archive Toulouse Archive Ouverte (OATAO) OATAO is an open access repository that collects the work of Toulouse researchers and

    Get Price
  • Aqueous extraction of residual oil from sunflower press

    Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: Feasibility study Evon, Philippe and Vandenbossche, Virginie and Pontalier, Pierre-Yves and Rigal, Luc Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: Feasibility study.

    Get Price
  • Aqueous extraction of residual oil from sunflower press

    The objective of this study was to evaluate the feasibility of an aqueous process to extract the residual oil from sunflower press cakes using a co-rotating twin-screw extruder. Two different configurations were tested: the expression from whole seeds followed by the aqueous extraction, in two successive apparatus or in the same one.

    Get Price
  • Aqueous extraction of residual oil from sunflower press

    Oil yield was better when the expression and the aqueous extraction were conducted in the same extruder. For all the trials carried out using such a configuration, the corresponding cake meal contained less than 10% residual oil, and the total oil yield was 78% in the best operating conditions.

    Get Price
  • Aqueous extraction of residual oil from sunflower press\ud

    The objective of this study was to evaluate the feasibility of an aqueous process to extract the residual oil from sunflower press cakes using a co-rotating twin-screw extruder. Two different configurations were tested: the expression from whole seeds followed by the aqueous extraction, in two successive apparatus or in the same one.

    Get Price
  • Aqueous extraction of residual oil from sunflower press\ud

    The objective of this study was to evaluate the feasibility of an aqueous process to extract the residual oil from sunflower press cakes using a co-rotating twin-screw extruder. Two different configurations were tested: the expression from whole seeds followed by the aqueous extraction, in two successive apparatus or in the same one.

    Get Price
  • EXTRACTION OF OIL AND MINOR LIPIDS FROM COLD

    EXTRACTION OF OIL AND MINOR LIPIDS FROM COLD-PRESS RAPESEED CAKE WITH SUPERCRITICAL CO2 E. Uquiche1,2*, oil (e.g., extra virgin olive oil) and a residual press cake (Johnson, 1997). The residual press cake (as Extraction of Oil and Minor Lipids from Cold-Press Rapeseed Cake with Supercritical CO 2 587

    • Published in: Brazilian Journal of Chemical Engineering · 2012Authors: Edgar Uquiche · V Romero · Jaime Ortiz · J M Del ValleAffiliation: University of La Frontera · University of Chile · Pontifical Catholic University of Chile
    • [PDF]Open Archive Toulouse Archive Ouverte (OATAO)

      Rigal, Luc Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: Feasibility study. (2009) Industrial Crops and Products, vol. 2 (n° 2-3). pp. 455-465. ISSN 0926-6690 Open Archive Toulouse Archive Ouverte (OATAO) OATAO is an open access repository that collects the work of Toulouse researchers and

      • Published in: Industrial Crops and Products · 2009Authors: Philippe Evon · Philippe Evon · Virginie Vandenbossche · Virginie Vandenbossche · Pi…Affiliation: University of Toulouse · Institut National De La Recherche AgronomiqueAbout: Volumetric flow rate · Crop · Extrusion · Filtration · Sunflower · Operant conditioning
      • Extraction of oil from jatropha seeds using a twin screw

    Twin-screw extrusion technology for vegetable oil. Evon et al. (2009) assessed a second extruder passage aiming at the aqueous extraction of the cake residual oil, using the same twin-screw extruder, but with a configuration based on the one previously used for the aqueous extraction of whole sunflower seeds (Evon et al., 2007).

    Get Price
  • Extraction of Coriander Oil Using Twin-Screw Extrusion

    Extraction of Coriander Oil Using Twin-Screw Extrusion: Feasibility Study and Potential Press Cake Applications Vandenbossche V, Pontalier PY, Rigal L (2009) Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: feasibility study. Rigal L (2010) Thermo-mechanical behaviour of the raffinate resulting

    Get Price
  • WO2008024840A2 - Aqueous processing of oilseed press cake

    Carbohydrase enzyme treatments of a wet milled slurry of canola press cake followed by alkali extraction resulted in only ~ 3-5% increase in oil and protein liquefaction from the starting canola press cake.

    Get Price
  • Manufacturing of renewable and biodegradable fiberboards

    Manufacturing of renewable and biodegradable fiberboards from cake generated during biorefinery of sunflower whole plant in twin-screw extruder: Influence of thermo-pressing conditions Aqueous extraction of residual oil from sunflower press cake using a twin-screw extruder: feasibility study Thermo-mechanical behaviour of the raffinate

    • Published in: Polymer Degradation and Stability · 2012Authors: Philippe Evon · Philippe Evon · Virginie Vandenbossche · Virginie Vandenbossche · Lu…Affiliation: Institut National De La Recherche Agronomique · University of ToulouseAbout: Young's modulus · Biodegradation · Molding · Pressing
    • SCREW CONFIGURATION EFFECTS ON RESIDENCE TIME

      Evon, V. Vandenbossche, P.Y. Pontalier and L. Rigal, Direct extraction of oil from sunflower seeds by twin-screw extruder according to an aqueous extraction process: Feasibility study and influence of operating conditions, Industrial Crops and Products, 26, 3, (351), (2007).

      Get Price
    • Pierre-yves Pontalier | Institut National Polytechnique de

      Aqueous extraction of sunflower oil is a reasonable environment-friendly alternative to the solvent extraction. It can even be realized directly from the whole plant using the

      Get Price
    • New thermal insulation fiberboards from cake generated

      The density of the insulation materials varied from 500 to residual oil from sunflower press cake using a twin-screw extruder: feasibility 858 kgjm3 , and the !east dense fiberboard was produced under study.Ind. Crops Prod. 29 (2-3), 455-465.

      Get Price
    • US20100234569A1 - Aqueous processing of oilseed press cake

      The products of this process were a crude canola expeller oil and a residual double pressed canola press cake with ˜8% residual oil content. This canola meal was not solvent extracted. The proximate analysis of the process intermediate samples for these two presscake products are presented in Tables 6 & 7.

      Get Price
    • Less residual oil efficient oil producing sunflower seeds

      NRI carries out research and surveys; develops pilot-seal plant, machinery and processes . Coconut oil extraction using a low-pressure bridge press (NRI . Sunflower seed . Oil- cake contains the residual oil, all of the meal and some water. . Extraction efficiency tends to be related to the oil

      Get Price
    • Quality differences between pre-pressed and solvent

      Practical applications: Traditionally, high yields of vegetable oils are obtained by pre-pressing the seeds, followed by solvent extraction of the residual oil from the press cake. The solvent extraction leads to higher oil yields, but is expected to affect the composition and quality of the oil, and has moreover negative environmental impacts.

      • Published in: European Journal of Lipid Science and Technology · 2010Authors: Vera Van Hoed · Cyrine Ben Ali · Mejri Slah · Roland VerheAffiliation: Ghent UniversityAbout: Vegetable oil · Pressing · Solvent · Food processing · Chemical composition · Food qu…
      • Sunflower Oil Cake, Sunflower Oil Cake Suppliers and

      1. Small model home use oil press This model is used to home, mainly produce soybean, sunflower, peanut, sesame, copra, palm kernel and so on, easy operate, low residual, high oil yield.

      Get Price
    • Exploratory Analysis for Characterization of Solvent

      Residual Oil Extraction from Rapeseed Cake Using Different Solvents. Solvent extraction of oil from rapeseeds is mainly being done by hexane [26, 27]; however, several authors have mentioned the use of diethyl ether and petroleum ether for doing the same [10, 28, 29, 30].

      Get Price
    • Quality differences between pre-pressed and solvent

      Practical applications: Traditionally, high yields of vegetable oils are obtained by pre-pressing the seeds, followed by solvent extraction of the residual oil from the press cake. The solvent extraction leads to higher oil yields, but is expected to affect the composition and quality of the oil, and has moreover negative environmental impacts.

      • Published in: European Journal of Lipid Science and Technology · 2010Authors: Vera Van Hoed · Cyrine Ben Ali · Mejri Slah · Roland VerheAffiliation: Ghent UniversityAbout: Vegetable oil · Pressing · Solvent · Food processing · Chemical composition · Food qu…
      • Advanced Processing Techniques for Biobased Product

      The aqueous extraction of the residual oil in wheat germ press cake with boric acid-NaOH (pH 8) buffer using fine ground germ and liquid solid ratio of 20 and extraction time of 0.5 h resulted in the highest oil yield, 79.64%.

      Get Price
    • OPTIMIZATION OF VISCOZYME-L ASSISTED EXTRACTION OF

      Aqueous extraction of residual oil from the sunflower press cake using a twin-screw extruder: Feasibility study. Ind.Crop Prod. 29: 455-465. Firatligil-Durmus, E., and Evranuz, O. (2010).

      Get Price
    • New Insulation Fiberboards from Sunflower Cake With

      water, allowing the aqueous extraction of sunflower oil (Evon et al., 2010a). A filtration section along the barrel allows an extract (filtrate) and a raffinate (cake) to be collected separately, and oil extraction yield attains 57%, under optimal operating conditions, with 14.3% residual cake dry matter oil content.

      • Published in: Journal of Animal Science · 2015Authors: Philippe Evon · Justine Vinet · Matthieu Rigal · Laurent Labonne · Virginie Vandenboss…Affiliation: University of ToulouseAbout: Sunflower · Thermal insulation · Compression molding
      • Experimental study of shea butter extraction – High

      Optimization of Aqueous Extraction Conditions of. machinery Effects of Extraction Method and Geographical Location on Physical Extraction Type and Oil Form cotton seed press New type sunflower seed and cake oil solvent extraction shea butter press machine - sunfloweroilmachine The residual plots of the yield show that the adopted model

      Get Price
    • US Patent for Method for recovering oil from plant seeds

      The oil that was still contained in the press cake, also referred to as residual oil, was extracted from aliquot portions of the crushed press cake according to Reference Example 6, and the phosphatide content was determined therein according to Reference Example 5. “Changes in composition and quality of sunflower oils during extraction

      Get Price
    • Isoelectric protein precipitation from mild-acidic

      Isoelectric protein precipitation from mild-acidic extracts of de-oiled sunflower (Helianthus annuus L.) press cake. the utilisation of oil cakes and meals originating from sunflower oil extraction is still restricted to the application as animal feed . d denaturation enthalpy of sunflower seed de-oiled press cake…

      Get Price
    • Solvent and enzyme-aided aqueous extraction of goldenberry

      Solvent and enzyme-aided aqueous extraction of goldenberry ( Physalis peruviana L . ) pomace oil: impact of processing on composition and quality of oil and meal

      • Published in: European Food Research and Technology · 2008Authors: Mohamed Fawzy Ramadan · Mahmoud Sitohy · Joergthomas MoerselAffiliation: Zagazig University · Technical University of BerlinAbout: Biotechnology · Solvent · Enzyme · Fatty acid · Chemical composition · Meal
      • soybean solvent oil extraction process machinery in Russia

      List of Global Solvent Extraction Companies. Oil press,Rice bran oil machinery,Sunflower mill,Soybean production line,Peanut Production line,Small Scale Edible Machine,Oil Seeds Pretreatment and Prepress Plant,Oil Cake Solvent Extraction Refining plant,Biomass Diesel Equipments,,,.

      Get Price
    • Philippe EVON (BSc, PhD) - Google Scholar Citations

      This "Cited by" count includes citations to the following articles in Scholar. The ones marked * may be different from the article in the profile.

      Get Price
    • Extraction of Coriander Oil Using Twin-Screw Extrusion

      The lowest press cake’s residual oil content (15.0 % of the dry matter) was obtained under the following operating conditions (trial 9): (2010) Thermo-mechanical behaviour of the raffinate resulting from the aqueous extraction of sunflower whole plant in twin-screw extruder: manufacturing of biodegradable agromaterials by thermo-pressing.

      Get Price
    • Oxidative Medicine and Cellular Longevity - Hindawi

      The residual biomass of coffee, originated in the food industry after oil extraction from coffee beans, called coffee beans residual press cake, has attracted interest as a

      Get Price
    • Home Use Manual Sunflower Oil Press – Make Healthy Oil

      Prepare and press oilseeds to get the maximum amount of sunflower oil with the minimum amount of effort. This easy-to-use oil expeller works with a hand crank. It can grind and presses dried, shelled sunflower seeds and expels the oil from one spout and solid matter from the other.

      Get Price
    • What are the edible oils extracted by direct solvent

      Solvent extraction is sometimes used to extract oil from the hard palm kernel. The most common process for crushing sunflower and canola seeds is to use a mechanical press to get out about 60% of the oil and then feed the press cake to a solvent extraction plant.

      Get Price

    • Effect of the type and level of hydration of alcoholic

      Effect of the type and level of hydration of alcoholic solvents on the simultaneous extraction of oil and chlorogenic acids from sunflower seed press cake. Authors. Nayara K Scharlack,

      Get Price

    • Carotenoids and vitamin E in seed, press cake and oil of

      Carotenoids and vitamin E in seed, press cake and oil of rapeseed, sunflower, flax and safflower mainly extraction procedures, analyses (chromatography conditions and used standards) and statistical evaluation see FRANKE et al. 2010. RESULTS AND DISCUSSION.

      Get Price

    • Sunflower meal - price from the manufacturer

      Sunflower meal is a product obtained after making sunflower oil, by pressing and extraction of prepared seeds. Pressing is squeezing out a fatty liquid, and extraction can extract residual oil by adding organic substances. If 10-15% of vegetable oil remains in the cake, then it is only 1

      Get Price
    • Mini Home Use Seed Oil Expeller - Oil Press Machines for

      You can use it to press a various types of oil seed in our daily life such as peanut, sesame, canola seed, camellia seed, flax seed, sunflower seed etc.. Oil Press, expeller, Home expeller, Mini expeller,

      Get Price
    • Researchpaper Development of a Screw Press for Palm Oil

      Development of a Screw Press for Palm Oil Extraction O. A. Adetola, J. O. Olajide and A. P. Olalusi Abstract- A palm oil screw press was designed, fabricated and evaluated… Log In Register Most Popular

      Get Price
    • Original:Small Scale Vegetable Oil Extraction 6

      Coconut oil extraction from coconut gratings using the ram press Sun-dried coconut gratings containing approximately 3% moisture can be processed in a ram press. The throughput in a CAMARTEC BP-30 press, of gratings heated to 60°C, is 3.9 kg/in, yielding 2.46 1 of high quality oil.

      Get Price
    • POTENTIAL USE OF Crambe abyssinica PRESS CAKE AS AN

      residual oil on adsorption efficiency. The removal of residual oil by hexane extraction provided an increase in adsorption efficiency from 73 to 79% after 6 h adsorption. Adsorbed amounts after 6 h were 13.2 and 14.1 mg g-1 for the crambe press cake before and after residual oil extraction, respectively, without any thermal treatment.

      Get Price

    • US Patent for Method for recovering oil from plant seeds

      The oil that was still contained in the press cake, also referred to as residual oil, was extracted from aliquot portions of the crushed press cake according to Reference Example 6, and the phosphatide content was determined therein according to Reference Example 5. “Changes in composition and quality of sunflower oils during extraction

      Get Price
    • Fat and oil processing› Home› Oil Refining

      Under ideal conditions the oil content of the hydraulic-press cake can be reduced to about 3 percent, but in practical operation a 5 percent level is average. most of the residual oil is easily removed with solvents. A typical extraction system consists of (1) cleaning to remove tramp iron, dirt, foreign weed seeds, and stones, (2) removing

      Get Price

    • 30-50t Soybean Oil Cake Solvent Extraction Plant – Grain

      Instead of mechanical pressing, we get soybean oil by extracting it from solvent extraction plant. At first An undelinted seed composition is about:8-10% of lint, 18-22% of oil, 30-35% of meal and 30-35% of hulls. In order For recovery of residual left over oil in the cake, the cake is subjected to solvent extraction process. Send Inquiry

      Get Price